eAngler.com is under construction and will reopen soon.
Home
> Clymer MerCruiser Alpha One, Brave One, Two & Three Stern Drives 1986-1994
| Pin It |
|
 |
 |
 |  |  |
| MerCruiser Alpha One, Bravo One, Two and Three Stern Drives, 1986-1994 Part #: B742 648 pages CHAPTER ONE / GENERAL INFORMATION CHAPTER TWO / TOOLS AND TECHNIQUES CHAPTER THREE / TROUBLESHOOTING CHAPTER FOUR / LUBRICATION, MAINTENANCE AND TUNE-UP CHAPTER FIVE / LAY-UP, COOLING SYSTEM SERVICE AND FITTING OUT CHAPTER SIX / GM INLINE ENGINES Removal installation / Valve cover / Intake exhaust manifolds / Rocker arm assemblies / Crankshaft pulley and torsional damper / Timing gear cover and seal / Camshaft / Oil pan / Oil pump / Cylinder head / Valves and valve seats / Valve lifters / Piston connecting rod assembly / Rear main oil seal / Crankshaft / Flywheel / Cylinder block / Core plug /Specifications CHAPTER SEVEN / MERCRUISER INLINE ENGINES Removal installation / Valve cover / Intake manifold / Rocker arm assemblies / Alternator rotor/stator / Front cover, seals and circulating pump / Timing chain and sprockets / Camshaft / Oil pan pump / Cylinder head / Valves and valve seats / Valve lifters / Piston/connecting rod assembly / Crankshaft / Flywheel housing, coupler and flywheel / Cylinder block / Core plug /Specifications CHAPTER EIGHT / GM V6 AND V8 ENGINES Removal installation / Valve covers / Intake manifold / Exhaust manifold / Rocker arms / Valve lash except Mark V big blocks and Generation II V6 engines / Crankshaft pulley and torsional damper / Crankcase front cover and oil seal / Timing chain and sprockets / Balance shaft V6 models serial No. OF000001-on / Camshaft / Oil pan pump / Cylinder head / Valves and seats / Valve lifters / Piston/connecting rod assembly / Rear main oil seal / Crankshaft / Flywheel / Cylinder block / Core plug /Specifications CHAPTER NINE / FUEL DELIVERY SYSTEM Flame arrestor / Carburetors / Fuel pump and anti-siphon devices /Specifications CHAPTER TEN / COOLING SYSTEM Thermostat / Engine circulating pump / Stern drive water pump / Drive belt / Cooling system maintenance /Specifications CHAPTER ELEVEN / ELECTRICAL SYSTEMS Charging system / Direct drive alternator charging system / Starting system / Ignition system / Breaker point distribution / Thunderbolt IV ignition / DDIS ignition / EST ignition / Ignition coil / Ignition resistor wire (breaker point ignition) / Solenoids / Oil pressure switch sender unit / Water temperature sending unit / Electrical protection / Wiring harness with audio warning system /Specifications CHAPTER TWELVE / MERCRUISER DRIVE SYSTEM Mercruiser Alpha One drive / Mercruiser Bravo One, Bravo Two and Bravo Three drive /Specifications CHAPTER THIRTEEN / DRIVE SHAFT HOUSING Alpha One and Alpha One Generation II drive / Bravo One, Bravo Two and Bravo Three drive /Specifications CHAPTER FOURTEEN / GEARCASE HOUSING (LOWER UNIT) Alpha One drive / Bravo One and Bravo Two drive / Bravo Three /Specifications CHAPTER FIFTEEN / BELL HOUSING, GIMBAL BEARING AND GIMBAL RING Exhaust bellows tube / Shift cable / Gimbal bearing / Bell housing / Water hose and water tube / Gimbal ring, swivel shaft and steering lever service / Gimbal housing /Specifications CHAPTER SIXTEEN / POWER TRIM AND TILT SYSTEMS Low-pressure pump system / Auto trim system / Trim cylinders /Specifications CHAPTER SEVENTEEN / STEERING SYSTEMS Mechanical steering system / Power steering system /Specifications CHAPTER EIGHTEEN / CORROSION PROTECTION SYSTEMS Zinc anodes / Continuity devices / Galvanic isolator / Mercathode system / Corrosion protection test /Specifications INDEX WIRING DIAGRAMS Models covered: 1986 1987 1988 1989 1990 1991 1992 1993 1994 MERCRUISER ALPHA ONE 1986 1987 1988 1989 1990 1991 1992 1993 1994 MERCRUISER BRAVO ONE 1986 1987 1988 Exclusive Online Only products are products with a catalog number beginning with the letters MP or EP. Example: MP0021. We are committed to shipping your order as quickly as possible. In the event that you wish to cancel this order, the cancellation must take place within 2 hours from the time the order was placed. We are unable to cancel your order after this time period because your order is already in the fulfillment process. Online Only products require a Return Merchandise Authorization (RMA) from eAngler.com customer service department. Click Here for Complete Return and Exchange Policies for Exclusive Online Products |
Clymer MerCruiser Alpha One, Brave One, Two & Three Stern Drives 1986-1994 Reviews
